Product ID:M8-086 MIL-C-22750E, GRAY 36375, COMP A
MSDS Date:10/11/1993
FSC:8010
NIIN:01-316-3038
Kit Part:Y
MSDS Number: BVBPX

CRAWFORD LABS, INC

4165 S EMERALD AVE
CHICAGO, IL 60609
US

Emergency Phone: 312-433-1307

Info Phone: 312-376-7132

Preparer: DAVID SCHMETTERER

Cage: 5V430

CRAWFORD LABORATORIES, INC

CHICAGO, IL 60609 US

Telephone: 312-376-7132

Cage: 5V430

METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 71.2 MM HG)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 18%

OSHA PEL 100 PPM

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

DILUENT 8

CAS: 68609-97-2

Fraction By Weight: 2.6%

REACTION PRODUCTS OF EPICHLOROHYDRIN & BISPHENOL A

CAS: 25085-99-8

Fraction By Weight: 25%

TOLUENE (SARA III) (VAPOR PRESSURE 38 MM HG)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 4.0%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

BENZENE (SARA III) (TOLUENE CONTAINS A TRACE OF BENZENE)

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: TRACE

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

100 SOLVENT (VAPOR PRESSURE 9 MM HG)

CAS: 64742-95-6

Fraction By Weight: 2.3%

OSHA PEL 50 PPM

ACGIH TLV: 50 PPM

TITANIUM OXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 7.2%

ACGIH TLV: 10 MG/M3

AMORPHOUS SILICA (0-10% IN TITANIUM OXIDE)

CAS: 112926-00-8

RTECS: VV8850000

ALUMINIUM HYDROXIDE (0-9% IN TITANIUM OXIDE)

CAS: 21645-51-2

RTECS: BD0940000

Fraction By Weight: 0.9%

DIATOMACEOUS EARTH

CAS: 68855-54-9

Fraction By Weight: 17%

ACGIH TLV: 0 PPM

SILICON DIOXIDE (CRYSTALLINE) (MAY BE RELEASED BY SANDING

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 9.3%

OSHA PEL 0.1 MG/M3

ACGIH TLV: 0.1 MG/M3

Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:ACUTE TOXICITY, RESULTING IN
HEADACHES, DIZZINESS, NAUSEA, AND LOSS OF CONSCIOUSNESS. SEVERE
EYE IRRITATION POSSIBLY RESULTING IN PERMANENT DAMAGE. IRRITATED
MUCOUS MEMBRANES. VOMITING DUE TO INGESTI ON. DEFATTING & DRYING OF
THE SKIN. SENSITIZATION AFTER REPEATED CONTACT.
Explanation of Carcinogenicity:IARC HAS CONCLUDED THAT THERE IS LIMITED
EVIDENCE FOR THE CARCINOGENICITY OF CRYSTALLINE SILICA TO HUMANS.

First Aid:EYE:FLUSH LUKEWARM LOW PRESSR WATER 15 MIN,LIFTING
EYELIDS.GET MED AID. INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN IF
BREATH DIFFICULT.GIVE ARTIF RESPRTN IF NO BREATH.GET MED AID.KEEP
WARM & COMFORTABLE.NE VER GIVE UNCONSCIOUS PERSON LIQ. INGEST:CALL
DR IMMED.ONLY INDUCE VOMITING ON DR'S INSTRUCTIONS.IF VOMITING
OCCURS,KEEP HEAD BELOW HIPS (PREVENT ASPIRATION).NOTHING BY MOUTH
TO UNCONSCIOUS PERSON. *

Flash Point Method:SCC
Flash Point:22.0F,-5.6C
Lower Limits:0.9
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO KEEP EXPOSED CONTAINERS
COOL & KEEP FLAMMABLE STRUCTURES WET. DO NOT ENTER FIRE AREA
WITHOUT PROTECTION (HAZARDOUS DECOMP MAY BE PRESENT).
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVERHEATED.

Spill Release Procedures:WARNING - FLAMMABLE. ELIMINATE ALL IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
SOAK UP WITH AN ABSORBENT AND PLACE IN NON-LEAKING CONTAINERS. SEAL
TIGHTLY FOR PROPER DIS POSAL.

Handling and Storage Precautions:FLAMMABLE.KNOW DOT REGS BEFORE
TRANSPORT.HOT ORGANIC CHEM VAPORS SUSCEPTIBLE TO SUDDEN SPONTANEOUS
COMBUSTION WHEN MIXED W/AIR.IGNITION MAY OCCUR AT**
Other Precautions:**TEMP BELOW AUTOIGNIT TEMP.IGNIT TEMP DECREASE
W/INCREASING VAPOR VOLUME & VAPOR/AIR CONTACT TIME & PRESSR
CHANGE.HOT VAPOR MAY IGNITE W/AIR BELOW AUTOIGNITN.IGNITN MAY OCCUR
AT HIGH TEMP W/SUDDEN IN GRESS OR ESCAPE OF VAPORS TO ATMOSPHERE.

Respiratory Protection:IMPORTANT-MUST PROVIDE ADEQUATE VENTILATION TO
MAINTAIN VAPOR CONCENTRATION BELOW THE ESTABLISHED TLV LIMIT AS
GIVEN BY OSHA. IN MORE CONFINED AREAS A NIOSH-MSHA APPROVED
RESPIRATOR EQUIPPED WITH ORGA NIC VAPOR CARTRIDGE SHOULD BE WORN.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION. SEE RESPIRATORY
PROTECTION.
Protective Gloves:USE RUBBER GLOVES
Eye Protection:WEAR APPROVED SAFETY GOGGLES/FACE SHIELD
Other Protective Equipment:HAVE EYE BATH AND SAFETY SHOWER AVAILABLE.
Work Hygienic Practices:DO NOT REUSE CONTAMINATED CLOTHING OR SHOES.
Supplemental Safety and Health
* FIRST AID CONT'D: SKIN CONTACT - FLUSH WITH WATER WHILE REMOVING
CONTAMINATED CLOTHING AND SHOES. FOLLOW BY WASHING WITH SOAP AND
WATER. DO NOT REUSE CONTAMINATED CLOTHING OR SHOES. IF IRRITATION
PE RSISTS, GET MEDICAL ATTENTION.

HCC:F3
Boiling Pt:B.P. Text:174 TO 344F
Vapor Density:> AIR
Spec Gravity:1.25
Viscosity:62 KU
Evaporation Rate & Reference:3.71 X N-BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:GRAY LIQUID / SOLVENT ODOR
Percent Volatiles by Volume:38.3
Corrosion Rate:NOT CORR

Stability Indicator/Materials to Avoid:YES
MAY BE INCOMPATIBLE WITH OXIDIZING AGENTS AND STRONG ALKALIES.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAMES, AND
INCOMPATIBILITES.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER
TOXIC GASES.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH CURRENT
LOCAL, STATE, AND FEDERAL REGULATIONS. CONTACT AN APPROVED DISPOSAL
FACILITY. EPA HAZARDOUS WASTE CODE: D001. HAZARDOUS WASTE
CHARACTERISTIC: IGNITABLE. DIS POSAL METHOD: FUEL CONSUMPTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.